Email this article 
Open Access
Subscription or Fee Access
New Extended Simulation Method at Out-Design Operating Conditions for Cooling Towers
(*) Corresponding author
DOI: https://doi.org/10.15866/ireme.v9i1.4672
Abstract
The present article describes an improved formulation of Arns and Klenke’s Simplified Model, based on Merkel’s Standard Model. The point of this is to enable better simulation of the performances for open counterflow cooling towers under operating conditions different from those set in the manufacturers’ manuals. It aims to demonstrate that it is possible to improve Arns and Klenke’s used models to simulate the cooling towers and enable these models to evaluate their performances in greater detail. To complement the comparative study of these two models, the Simplified Model has been extended to two new cases. Our contribution consists in proposing an innovative method that makes it possible on the one hand to compensate for the shortage of validation data since manuals do not mention all the necessary performances for simulation, and on the other hand to offer a new way of validating the obtained results. The suggested method is based on the use of the stationary operating states of the tower as a means to validate simulation. Numerical results have been successfully compared with those obtained by the Standard Method. The results are satisfactory, show the limitations of each model and open ways to further improvements.
Copyright © 2015 Praise Worthy Prize - All rights reserved.
Keywords
References
P.ARNEODO, V.GIARTO, A.MAZZA, System simulation, International Energy Agency, 1990,Annex 10.
Ch. ARNS, Zur Beurteilung von Prospekt-und Angebotsangaben ϋberkϋhltϋrme, Kältetechnik- Klimatisierung, 10/1970, pp.335-339.
W. KLENKE, Zur Einheitlichen Beurteilung und Berechnung von Gegenstrom und Kreuzstrom Kϋhltϋmen, Kältetechnik- Klimatisierung, 10/1970, pp.322-330.
KERN, D.Q, Process Heat Transfer (Mc Graw Hill, New York, 1950, pp.563-623).
ASHARE, Refrigerating and Air Conditioning Engineers, Handbook Fundamentals, ( American Society of Heating, Atlanta,1981, pp. 3.1-3.16)
J.W. Sutherland, Analysis of Mechanical Draught Counterflow Air/Water cooling towers, Journal of heat transfer, Vol. 105, pp. 576-583, 1983.
http://dx.doi.org/10.1115/1.3245624
R.L. Webb, A. Villacres, Algorithms for Performance Simulation of Cooling Towers, Evaporative Condensers and Fluid Coolers, (ASHARE Transactions, Vol. 90, Part 2, 1984)
http://dx.doi.org/10.1080/01457638508939622
R.L. Webb, A Unified theoretical treatment for Thermal Analysis of Cooling Towers, Evaporative Condensers, and Fluid Coolers, (ASHRAE Transactions, Vol. 90 , Part2, 1984)
H.C. Peitsman, U.J. Nicolas, System simulation ’Liquid chilling system’(TNO Institude of Applied Physics, April 19,1988)
Medardo Serna-Gonzalez, José M. Ponce-Ortega, Arturo Jiménez-Gutiérrez, MINLP optimization of mechanical draft counter flow wet-cooling tower, Chemical Enginnering Research And Design ,pp614-625, 88(2010).
http://dx.doi.org/10.1016/j.cherd.2009.09.016
Jean Lebrun, Thermodynamique Appliquée (Liège, Janvier 1989)
JC. Kloppers, DG. Kroger, A critical investigation into the heat and Mass Transfer analysis of counterflow wet-cooling towers, International journal of heat and mass transfer, Vol. 48, n. 1, pp.765-777, 2005c.
http://dx.doi.org/10.1016/j.ijheatmasstransfer.2004.09.004
JC. Kloppers, DG. Kroger, Cooling tower performance evaluation:Merkel, Poppe and e-NTU methods of analysis, Journal of engineering for Gas Trubines and Power ,Vol. 127, n. 1, pp.1-7, 2005b.
http://dx.doi.org/10.1115/1.1787504
M. Lucas, P.J. Martinez, J. Ruiz, A.S. Kaiser, A. Viedma, On the influence of psychometric ambient conditions on cooling tower drift deposition, International Journal of Heat and Mass Transfer Vol.53, pp.594-604, 2010
http://dx.doi.org/10.1016/j.ijheatmasstransfer.2009.10.037
Medardo Serna-Gonzalez, José M. Ponce-Ortega, Arturo Jiménez-Gutiérrez, MINLP of mechanical draft counter flow wet-cooling towers, Chemical Engineering Resarch and Design, Vol. 88, pp.614-625, 2010.
http://dx.doi.org/10.1016/j.cherd.2009.09.016
ASHRAE, Systems and Equipment Cooling Towers, Handbook CD-HVAC , (Chapter 36, 2005)
ASHRAE, Systems and Equipment Cooling Towers, Handbook CD-HVAC, (Chapter 38, 2008)
J.R. Picardo, J.E. Variyar, The Merkel equation revisited: a novel method to compute the packed height of a cooling tower , Energy Conversion and Management , Vol. 57, pp.167-172, 2012.
http://dx.doi.org/10.1016/j.enconman.2011.12.016
J.R. Singham, Heat Exchanger Design Handbook (Hemisphere Publishing Corporation, New York , USA,1983).
A. Mohier, Thermodynamique(Édit. DELAGRAVE, Paris, 1965).
Abdi Ghezail, Simulation du fonctionnement d’une tour de refroidissement par la méthode standard et simplifiée, mémoire de magister(Master thesis), Dept. Mecanique, Ecole Nationale Polytechnique d’Oran (ENP D’Oran), Algeria, Juin 2011.
Thiao, S., Mar, A., Mbow, C., Youm, I., Solar Cooling System: Theoretical Study of Coefficient of Performance (COP) of a Solar Chiller Adsorption in the Site of CERER, (2014) International Journal on Energy Conversion (IRECON), 2 (5), pp. 147-150.
Thiao, S., Mar, A., Karbach, A., Youm, I., Experimental Study of Air Conditioning of the Building by Floor Cooling System, (2014) International Journal on Engineering Applications (IREA), 2 (3), pp. 85-88.
Refbacks
Please send any question about this web site to info@praiseworthyprize.com
Copyright © 2005-2024 Praise Worthy Prize
