Low Reynolds Number Investigation of the Flow Over a NACA 0012 Airfoil at Different Rainfall Rates

Eleni C. Douvi; Dionissios P. Margaris; Sotirios D. Lazaropoulos; Stylianos G. Svanas

doi:10.15866/ireme.v7i4.3813

Low Reynolds Number Investigation of the Flow Over a NACA 0012 Airfoil at Different Rainfall Rates

Eleni C. Douvi^(1*), Dionissios P. Margaris⁽²⁾, Sotirios D. Lazaropoulos⁽³⁾, Stylianos G. Svanas⁽⁴⁾

^(*) Corresponding author

Authors' affiliations

DOI: https://doi.org/10.15866/ireme.v7i4.3813

Abstract

The influence of different rain rates on the aerodynamic performance of the NACA 0012 airfoil with a low Reynolds number of 1×105 was investigated. Wind tunnel tests were conducted to determine lift and drag coefficients at various angles of attack in both dry and wet conditions and the results were compared to show the effects of Liquid Water Contents (LWC) at airfoil performance. Four different rainfall rates were simulated by injecting water droplets from commercial rain simulation nozzles upstream of the airfoil model, corresponding to LWCs of 20.548 g/m3, 37.745 g/m3, 41.096 g/m3 and 75.491 g/m3. A computational fluid dynamics code was utilized to gain further knowledge on the flow field. The simulation of rain was accomplished by using the two-phase flow Discrete Phase Model. It was concluded that degradation of aerodynamic performance increases with increasing LWC up to stall angle and stall is delayed for all rain rates. The computational results showed that larger droplets were more susceptible to droplet breakup than smaller droplets and generally breakup near regions with severe pressure gradients, close to the airfoil. The water film height and the location of rivulet formation on the upper surface of the airfoil are also presented.
Copyright © 2013 Praise Worthy Prize - All rights reserved.

Keywords

Aerodynamic Characteristics; Airfoil; Liquid Water Content; Rivulet Formation; Water Film

Full Text:

PDF

References

R.V. Rhode, Some Effects of Rainfall on Flight of Airplanes and on Instrument Indications (NACA TN 803, 1941).

P. Haines, J. Luers, Aerodynamic Penalties of Heavy Rain on Landing Airplanes, Journal of Aircraft, Vol. 20, n. 2, pp. 111-119, 1983.
https://doi.org/10.2514/3.44839

R.J. Hansman, M.F. Barsotti, Surface Wetting Effects on a Laminar Flow Airfoil in Simulated Heavy Rain, Journal of Aircraft, Vol. 22, n. 12, pp 1049-1053, 1985.
https://doi.org/10.2514/3.45248

Jr.E.C. Hastings, G.S. Manuel, Measurements of Water Film Characteristics on Airfoil Surfaces from Wind-Tunnel Tests with Simulated Heavy Rain, AIAA Paper, 1985.
https://doi.org/10.2514/6.1985-259

R.J. Hansman, A.P. Craig, Low Reynolds Number Tests of NACA 64-210, NACA 0012, and Wortmann FX67-K170 Airfoils in Rain, Journal of Aircraft, Vol. 24, n. 8, pp 559-566, 1987.
https://doi.org/10.2514/3.45476

J.R. Valentine, R.A. Decker, A Lagrangian-Eulerian Scheme for Flow around an Airfoil in Rain, International Journal of Multiphase Flow, Vol. 21, n. 4, pp 639-648, 1995.
https://doi.org/10.1016/0301-9322(95)00007-k

B.E. Thompson, J.Jang, M.R. Marrochello, Calculations of Rivulet Formation in the Surface-Water Flow over Wings in Rain, American Society of Mechanical Engineers, Fluids Engineering Division (Publication) FED 2, 1997.

J. Tan, M. Papadakis, M.K. Sampath, Computational Study of Large Droplet Breakup in the Vicinity of an Airfoil, (Technical Report, Washington, 2005).

H. Huang, H.C. Lu, Y.P. Xu, Z.W. Deng, Simulation and Quantitative Analysis of Effects of Heavy Rain on Aircraft Landing, Journal of System Simulation, Vol. 22, n. 11, pp. 2600-2603+2617, 2010.

M. Cai, E. Abbasi, H. Arastoopour, Analysis of the Performance of a Wind-Turbine Airfoil under Heavy Rain Conditions Using a Multiphase Computational Fluid Dynamics Approach, Industrial & Engineering Chemistry Research, Vol. 52, pp. 3266-3275, 2012.
https://doi.org/10.1021/ie300877t

F. Durst, D. Milojevic, B. Schonung, Eulerian and Lagrangian predictions of particulate two-phase flows: a numerical study, Applied Mathematical Modelling, Vol. 8, pp 101-115, 1984.
https://doi.org/10.1016/0307-904x(84)90062-3

G.M. Bezos, E.R. Dunham, G.L. Gentry, E.W. Melson, Wind Tunnel Aerodynamic Characteristics of a Transport-Type Airfoil in a Simulated Heavy Rain Enviroment, NASA Technical Paper 3184, 1992.
https://doi.org/10.2514/6.1985-258

Fluent Inc., Fluent 6.3 Documentation-User’s Guide, 2006

T.H. Shih, W.W. Liou, A. Shabbir, J. Zhu, A new k-ε eddy – viscosity model for high Reynolds number turbulent flows – model development and validation, Computers & Fluids, Vol. 24, pp 227-238, 1995.
https://doi.org/10.1016/0045-7930(94)00032-t

G.I. Taylor, The Shape and Acceleration of a Drop in a High Speed Air Stream, (Technical report, 1963).

Computational Fluid Dynamics (CFD) Preprocessor, Gambit 2.4 Documentation-User’s Guide, 2007.

B.E. Thompson, M.R. Marrochello, Rivulet Formation in Surface-Water Flow on an Airfoil in Rain, AIAA Journal, Vol. 37, n. 1, pp 45-49, 1999.
https://doi.org/10.2514/3.14121

E. Douvi, D. Margaris, Simulation of Heavy Rain Flow over a NACA 0012 Airfoil, Proceedings of International Conference on Experiments/ Process/ System Modelling/ Simulation/ Optimization, 4th IC-EpsMsO, Athens, 6-9 July 2011.

E. Douvi, D. Margaris, Aerodynamic Performance Investigation under the Influence of Heavy Rain of a NACA 0012 Airfoil for Wind Turbine Applications, (2012) International Review of Mechanical Engineering (IREME), 6 (6), pp. 1228-1235.

Refbacks

There are currently no refbacks.

Username
Password
Remember me