Open Access Open Access  Restricted Access Subscription or Fee Access

Increasing Energy Parameters of High-Speed Magneto-Electric Generator for Autonomous Objects

Flur Ismagilov(1), Irek Khayrullin(2), Vyacheslav Vavilov(3), Vladimir Bekuzin(4), Valentina Ayguzina(5*)

(1) Department of Electromechanics, Ufa State Aviation Technical University, Russian Federation
(2) Department of Electromechanics, Ufa State Aviation Technical University, Russian Federation
(3) Department of Electromechanics, Ufa State Aviation Technical University, Russian Federation
(4) Department of Electromechanics, Ufa State Aviation Technical University, Russian Federation
(5) Department of Electromechanics, Ufa State Aviation Technical University, Russian Federation
(*) Corresponding author


DOI: https://doi.org/10.15866/irease.v10i2.11708

Abstract


This article presents the research on the various methods of improving the energy characteristics of high-speed magneto-electric generators. The modeling of the magneto-electric generator with permanent magnets made of various alloys was presented. The effectiveness assessment of the Halbach magnetic system was presented. The use of the Halbach magnetic system improves the high-speed magneto-electric generator power by 7-15% while significantly increasing the induction in the stator core. The short-circuit current is increased (up to 2200 A); this provided 1.5 times overload of magneto-electric generators within 5 minutes. The significant increase of magneto-electric generator power can be reached through the increase of the linear current load or by joint increase of the linear current load and the magnetic induction in the air gap. Based on the described methods, the calculations for the high-speed 450 kW magneto-electric generator with a mass of 47 kg is performed taking into account the armature reaction magnetic field, the changes in the total harmonic distortion and other changes of magneto-electric generator parameters depending on the high-coercitivity permanent magnets poles arc. The obtained results can be practically applied in the design of high-speed magneto-electric generator for the power supply system of autonomous objects.
Copyright © 2017 Praise Worthy Prize - All rights reserved.

Keywords


High-Speed Magneto-Electric Generator; Halbach Magnetic System; High-Coercivity Permanent Magnets; Autonomous Objects

Full Text:

PDF


References


A.V. Levin, S.M. Musin, S.A. Kharitonov, K.L. et al., Elektricheskiy samolet: kontseptsiya i tekhnologii (in Russian, Ufa, UGATU, 2014.)
http://dx.doi.org/10.13108/2014-6-4-108

A. Nagorny, N. Dravid, R. Jansen, B. Kenny, Design Aspects of a High Speed Permanent Magnet Synchronous Motor/Generator for Flywheel Applications in NASA/TM–2005–213651 (2005), 1–7.
http://dx.doi.org/10.1109/iemdc.2005.195790

E. Ganev, Advanced Electric Generators for Aerospace More Electric Architectures in SAE Technical Paper 2010-01-1758 (2010).
http://dx.doi.org/10.4271/2010-01-1758

V. V. Magin, V. A. Klabukov, A. V. Rogoza, Vysokooborotnyy generator na elektromagnitnykh podshipnikakh dlya energeticheskikh ustanovok kosmicheskogo naznacheniya (in Russian) in Trudy MAI. No. 45 (2011), 1-16.
http://dx.doi.org/10.21313/hawaii/9780984566600.003.0005

Ismagilov, F., Vavilov, V., Research of the Magnetic Field of High-Speed Magnetoelectric Generator, (2016) International Review of Electrical Engineering (IREE), 11 (2), pp. 136-141.
http://dx.doi.org/10.15866/iree.v11i2.8158

Ismagilov, F., Vavilov, V., Bekuzin, V., Ayguzina, V., High-Speed Magneto-Electric Slotless Generator, Integrated into Auxiliary Power Unit: Design and Experimental Research of a Scaled-Size Prototype, (2016) International Review of Aerospace Engineering (IREASE), 9 (5), pp. 173-179.
http://dx.doi.org/10.15866/irease.v9i5.10432

Vozdushnyy punkt strategicheskogo upravleniya proshel gosispytaniya (in Russian) [Online]. Available: http://minpromtorg.gov.ru/press-centre/news/#!vozdushnyy_punkt_strategicheskogo_upravleniya_proshel_gosispytaniya.

Bobtsov, A.A., Pyrkin, A.A., Ortega, R. et. all A robust globally convergent position observer for the permanent magnet synchronous motor in Automatica 61, 47-54
http://dx.doi.org/10.1016/j.automatica.2015.07.032

Z. Q. Zhu, David Howe Electrical Machines and Drives for Electric, Hybrid, and Fuel Cell Vehicles in Proceedings of the IEEE, , vol. 95, no. 4, (2007), 746–765.
http://dx.doi.org/10.1109/jproc.2006.892482

Chin Y.K.: A Permanent Magnet Synchronous Motor for Traction Application of Electric Vehicle, Electric Machines and Drive Conference, IEEE int., vol. 2 (2003), 1035–1041,
http://dx.doi.org/10.1109/iemdc.2003.1210362

Gieras J. F. High speed machines. Advancements in Electric Machines (Power Systems). 2008. Pp. 81–113.
http://dx.doi.org/10.1007/978-1-4020-9007-3_4

Hans-Christian Lahne, Dieter Gerling Investigation of High-performance Materials in Design of a 50000 rpm Highspeed Induction Generator for Use in Aircraft Applications (AST 2015), 1–10.
http://dx.doi.org/10.1109/ever.2016.7476345

Bailey C., Saban D., Guedes-Pinto P. Design of High-Speed Direct-Connected Permanent-Magnet Motors and Generators for the Petrochemical Industry in IEEE Transactions on Industry Applications. Vol. 45, no 3 (2009), 1159–1165.
http://dx.doi.org/10.1109/tia.2009.2018964

Borisavljevic A., Polinder H., Ferreira J. On the Speed Limits of Permanent-Magnet Machines in IEEE Transactions on Industrial Electronics. Vol. 57, no. 1 (2010), 220–227.
http://dx.doi.org/10.1109/tie.2009.2030762

Abdi B., Milimonfared J., Moghani J. Simplified Design and Optimization of Slotless Synchronous PM Machine for Micro-Satellite Electro-Mechanical Batteries in Advances in Electrical and Computer Engineering. Vol. 9, no. 3 (2009), 84–88.
http://dx.doi.org/10.4316/aece.2009.03015

Microw J. Optimal design of a set of permanent magnet generators with the same cross-section in Optoelectron. Electromagn. Appl. Vol. 12, no. 2 (2013), 678–693.
http://dx.doi.org/10.1590/s2179-10742013000200035

Zhang T., Xiaoting Y., Huiping Z. Strength Design on Permanent Magnet Rotor in High Speed Motor Using Finite Element Method in Telkomnika Indonesian Journal of Electrical Engineering. Vol.12, no. 3 (2014), 1758–1763.
http://dx.doi.org/10.11591/telkomnika.v12i3.4675

Hong D. K., Woo B. C., Lee J. Y., Ultra High Speed Motor Supported by Air Foil Bearings for Air Blower Cooling Fuel Cells in IEEE Trans. Magn. Vol. 48 (2012), 871–874.
http://dx.doi.org/10.1109/tmag.2011.2174209

Johnson D., Pillay P. Malengret M. High speed PM motor with hybrid magnetic bearing for kinetic energy storage in Conference Record - IAS Annual Meeting (IEEE Industry Applications Society).Vol. 1 (2001), 57–63.
http://dx.doi.org/10.1109/ias.2001.955392

Vavilov, V., Ismagilov, F., Khayrullin, I., Gumerova, M., Application of Hybrid Magnetic Bearings in Aviation Starter-Generators, (2014) International Review of Electrical Engineering (IREE), 9 (3), pp. 506-510.

Tuysuz, A., Steichen, M., Zwyssig, C., Kolar, J.W. Advanced cooling concepts for ultra-high-speed machines in 9th International Conference on Power Electronics - ECCE Asia: "Green World with Power Electronics", ICPE 2015-ECCE Asia 7168081, pp. 2194-2202.
http://dx.doi.org/10.1109/icpe.2015.7168081

Dieter Gerling, Mohammed Alnajjar. Six-Phase Electrically Excited Synchronous Generator for More Electric Aircraft, International Symposium on Power Electronics, Electrical Drives, Automation and Motion, 2016, pp. 7–13.
http://dx.doi.org/10.1109/speedam.2016.7525938

G. Dajaku, D. Gerling. Magnetic Radial Force Density of the PM Machine with 12teeth/10-poles Winding Topology, IEEE International Electric Machines and Drives Conference, IEMDC2009, Florida USA, May 3-6, 2009, 157-164
http://dx.doi.org/10.1109/iemdc.2009.5075434

F. R. Ismagilov, I. Kh. Khairullin, V. E. Vavilov, R.D. Karimiv, Osobennosti proyektirovaniya vysokooborotnykh elektromekhanicheskikh preobrazovateley energii s vysokokoertsitivnymi postoyannymi magnitami, rabotayushchikh v kratkovremennom rezhime (in Russian) in Izvestiya vysshikh uchebnykh zavedeniy. Elektromekhanika. No. 6 (2015), 45-53.
http://dx.doi.org/10.6060/tcct.20165910

Stotckaia, A., Polyakhov, N., Development and Investigation of Radial Active Magnetic Bearing's Mathematical Model, (2014) International Review of Electrical Engineering (IREE), 9 (3), pp. 519-526.

A.M. Sugrobov, A.M. Rusakov, Proyektirovaniye elektricheskikh mashin avtonomnykh ob"yektov (in Russian, Moscow, MEI, 2012).
http://dx.doi.org/10.2753/rss1061-1428031026

Elliott Energy Systems, Inc. [Online] Available: http://www.tapower.com.
http://dx.doi.org/10.1089/glre.2016.201011

G.P. Stanolevich, N.V. Fedoseyev, S.A. Timakov, S.L. Borisov, Ustoychivost' redkozemel'nykh SmCo magnitov k dlitel'nomu khraneniyu (in Russian) in Voprosy elektromekhaniki. Vol. 139 (2014), 29–34.
http://dx.doi.org/10.13187/vfp.2015.3.17

Vavilov V.Ye., Ismagilov F.R., Khayrullin I.KH., Karimov R.D. Vysokotemperaturnyye elektromekhanicheskiye preobrazovateli energii s vozmozhnost'yu integratsii v aviatsionnyy dvigatel'. perspektivy i problemy sozdaniya (in Russian) in Aviakosmicheskoye priborostroyeniye. No. 9 (2015), 48–56.

E. Ganev, M.L. Bansal, W.H. Warr, System and method for fault protection for permanent magnet machines (Patent US 7276871 B2, 02.10.2007).
http://dx.doi.org/10.1049/cp:20020153

E. Ganev, High-Reactance Permanent Magnet Machine for High-Performance Power Generation Systems, SAE Technical Paper Services 2006-01-3076, Power Systems Conference, New Orleans Louisiana, Nov. 7-9, 2006.
http://dx.doi.org/10.4271/2006-01-3076

Trekhfaznyye generatory s zhidkostnym okhlazhdeniyem GT60NZHCH 12K [Online] Available: http://segz.ru/generator-trexfaznyj-s-zhidkostnym-oxlazhdeniem-gt60nzhch-12k.

Co Huynh, Liping Zheng, Dipjyoti Acharya Losses in High Speed Permanent Magnet Machines Used in Microturbine Applications in Journal of Engineering for Gas Turbines and Power. Vol. 131, Issue 2 (2009), 1-6.
http://dx.doi.org/10.1115/1.2982151


Refbacks

  • There are currently no refbacks.



Please send any question about this web site to info@praiseworthyprize.com
Copyright © 2005-2020 Praise Worthy Prize