Open Access Open Access  Restricted Access Subscription or Fee Access

Experimental Assessment of Emissions in Low Displacement Diesel Engines Operating with Biodiesel Blends of Palm and Sunflower Oil

Sofia Orjuela(1*), Jhon Pabon(2), Marlen Fonseca(3)

(1) Universidad Francisco de Paula Santander, Colombia
(2) Universidad Francisco de Paula Santander, Colombia
(3) Universidad Francisco de Paula Santander, Colombia
(*) Corresponding author



This study presents the impact of biodiesel blends produced by sunflower oil residues and industrial palm oil residues on the performance parameters of a single-cylinder diesel engine. For the combustion performance analysis, the brake thermal efficiency and the brake specific fuel consumption parameters of the engine are investigated. The emissions study has focused on the measurement of CO2, NOx, CO, opacity, and HC of exhaust gases. The experiments have been performed for a loading condition of 20%, 40%, 60%, 80%, and 100%. The test fuels used have been commercial diesel (D100) and biodiesel blends (PB5, PB5SB2, and PB5SB4). The biodiesel blends PB5SB2 and PB5SB4 cause a reduction in the maximum pressure values and in the rate of heat release by 5.85% and 8.53%. Experimental results show that the content of the residual sunflower oil produces an increase in engine BSFC. This effect causes a decrease in engine BTE. However, the decrease caused has not affected the engine performance significantly. The biodiesel blends PB5SB2 and PB5SB4 cause a decrease in the emissions of HC, CO2, and CO. PB5SB2, and PB5SB4 fuels reduce the aforementioned emissions by 14%, 16%, and 22% compared to commercial diesel. The content of sunflower oil residues allows the reduction in smoke opacity. However, nitrogen oxide emissions have increased. The results obtained show that biodiesel produced from palm and sunflower oil residues provides a considerable reduction in large part of the emissions produced by a diesel engine without significantly affecting engine efficiency.
Copyright © 2021 Praise Worthy Prize - All rights reserved.


Biodiesel; Combustion; Diesel Engine; Emissions; Performance

Full Text:



Orozco, W., Acuña, N., Duarte Forero, J., Characterization of Emissions in Low Displacement Diesel Engines Using Biodiesel and Energy Recovery System, (2019) International Review of Mechanical Engineering (IREME), 13 (7), pp. 420-426.

Duarte Forero, J., Lopez Taborda, L., Bula Silvera, A., Characterization of the Performance of Centrifugal Pumps Powered by a Diesel Engine in Dredging Applications, (2019) International Review of Mechanical Engineering (IREME), 13 (1), pp. 11-20.

F. Consuegra, A. Bula, W. Guillín, J. Sánchez, and J. Duarte Forero, Instantaneous in-cylinder volume considering deformation and clearance due to lubricating film in reciprocating internal combustion engines, Energies, vol. 12, no. 8, p. 1437, 2019.

Omojola, A., Inambao, F., Onuh, E., Prediction of Properties, Engine Performance and Emissions of Compression Ignition Engines Fuelled with Waste Cooking Oil Methyl Ester - A Review of Numerical Approaches, (2019) International Review of Mechanical Engineering (IREME), 13 (2), pp. 97-110.

G. Amador, J.D. Forero, A. Rincon, A. Fontalvo, A. Bula, R.V. Padilla and W. Orozco, Characteristics of auto-ignition in internal combustion engines operated with gaseous fuels of variable methane number, Journal of Energy Resources Technology, vol. 139, no. 4, p. 042205, 2017.

Prada, G., Valencia, G., Duarte Forero, J., Characterization of Emissions in a Diesel Engine Using Biodiesel Blends Produced from Agro-Industrial Residues of Elaeis Guineensis, (2020) International Journal on Energy Conversion (IRECON), 8 (2), pp. 45-52.

G.A. Diaz, J.D. Forero, J. Garcia, A. Rincon, A. Fontalvo, A. Bula, and R.V. Padilla, Maximum power from fluid flow by applying the first and second laws of thermodynamics, Journal of Energy Resources Technology, vol. 139, no. 3, p. 032903, 2017.

Orozco, T., Herrera, M., Duarte Forero, J., CFD Study of Heat Exchangers Applied in Brayton Cycles: a Case Study in Supercritical Condition Using Carbon Dioxide as Working Fluid, (2019) International Review on Modelling and Simulations (IREMOS), 12 (2), pp. 72-82.

K. Zahan, M. Kano, Biodiesel Production from Palm Oil, Its By-Products, and Mill Effluent: A Review, Energies, vol. 11, p. 2132, 2018.

S. Bari, S. N. Hossain, Performance and emission analysis of a diesel engine running on palm oil diesel (POD), Energy Procedia, vol. 160, pp. 92–99, 2019.

B. Sajjadi, A. A. A. Raman, H. Arandiyan, A comprehensive review on properties of edible and non-edible vegetable oil-based biodiesel: Composition, specifications and prediction models, Renewable and Sustainable Energy Reviews, vol. 63, pp. 62–92, 2016.

Obregon, L., Valencia, G., Duarte Forero, J., Efficiency Optimization Study of a Centrifugal Pump for Industrial Dredging Applications Using CFD, (2019) International Review on Modelling and Simulations (IREMOS), 12 (4), pp. 245-252.

De la Hoz, J., Valencia, G., Duarte Forero, J., Reynolds Averaged Navier–Stokes Simulations of the Airflow in a Centrifugal Fan Using OpenFOAM, (2019) International Review on Modelling and Simulations (IREMOS), 12 (4), pp. 230-239.

S. Sumathi, S. P. Chai, A. R. Mohamed, Utilization of oil palm as a source of renewable energy in Malaysia, Renewable and Sustainable Energy Reviews, vol. 12, pp. 2404–2421, 2008.

J. C. Kurnia, S. V. Jangam, S. Akhtar, A. P. Sasmito, A. S. Mujumdar, Advances in biofuel production from oil palm and palm oil processing wastes: A review, Biofuel Research Journal, vol. 3, pp. 332–346, 2016.

W. Liew, K. Muda, M. Azraai, A. Affam, S. Loh, Agro-industrial waste sustainable management – a potential source of economic benefits to palm oil mills in malaysia, Journal of Urban and Environmental Engineering, vol. 11, pp. 108–118, 2017.

M. A. Ahmad Farid et al., Production of methyl esters from waste cooking oil using a heterogeneous biomass-based catalyst, Renewable Energy, vol. 114, pp. 638–643, 2017.

I. K. Hong, H. Jeon, H. Kim, S. B. Lee, Preparation of waste cooking oil based biodiesel using microwave irradiation energy, Journal of Industrial and Engineering Chemistry, vol. 42, pp. 107–112, 2016.

M. R. Anuar, A. Z. Abdullah, Ultrasound-assisted biodiesel production from waste cooking oil using hydrotalcite prepared by combustion method as catalyst, Applied Catalysis A: General, vol. 514, pp. 214–223, 2016.

M. Saifuddin, A. N. Boyce, Biodiesel production from waste cooking sunflower oil and environmental impact analysis, Kuwait Journal of Science, vol. 43, pp. 110–117, 2016.

J. Gupta, M. Agarwal, A. K. Dalai, Optimization of biodiesel production from mixture of edible and nonedible vegetable oils, Biocatalysis and Agricultural Biotechnology, vol. 8, pp. 112–120, 2016.

V. F. de Almeida, P. J. García-Moreno, A. Guadix, E. M. Guadix, Biodiesel production from mixtures of waste fish oil, palm oil and waste frying oil: Optimization of fuel properties, Fuel Processing Technology, vol. 133, pp. 152–160, 2015.

P. C. Jena, H. Raheman, G. V. Prasanna Kumar, R. Machavaram, Biodiesel production from mixture of mahua and simarouba oils with high free fatty acids, Biomass and Bioenergy, vol. 34, pp. 1108–1116, 2010.

J. M. Dias, M. C. M. Alvim-Ferraz, M. F. Almeida, Mixtures of Vegetable Oils and Animal Fat for Biodiesel Production: Influence on Product Composition and Quality, Energy & Fuels, vol. 22, pp. 3889–3893, 2008.

H. C. Ong et al., Biodiesel production from Calophyllum inophyllum-Ceiba pentandra oil mixture: Optimization and characterization, Journal of Cleaner Production, vol. 219, pp. 183–198, 2019.

S. Dharma et al., Optimization of biodiesel production process for mixed Jatropha curcas–Ceiba pentandra biodiesel using response surface methodology, Energy Conversion and Management, vol. 115, pp. 178–190, 2016.

N. Damanik, H. C. Ong, W. T. Chong, A. S. Silitonga, Biodiesel production from Calophyllum inophyllum− palm mixed oil, Energy Sources, Part A: Recovery, Utilization, and Environmental Effects, vol. 39, pp. 1283–1289, 2017.

H. Hadiyanto, I. Yuliandaru, R. Hapsari, Production of biodiesel from mixed waste cooking and castor oil, in MATEC Web of Conferences, 2018, vol. 156, p. 3056.

M. Elkelawy et al., Experimental studies on the biodiesel production parameters optimization of sunflower and soybean oil mixture and DI engine combustion, performance, and emission analysis fueled with diesel/biodiesel blends, Fuel, vol. 255, p. 115791, 2019.

J. F. Costa, M. F. Almeida, M. C. M. Alvim-Ferraz, J. M. Dias, Biodiesel production using oil from fish canning industry wastes, Energy Conversion and Management, vol. 74, pp. 17–23, 2013.

S. Sarikoç, I. Örs, S. Ünalan, An experimental study on energy-exergy analysis and sustainability index in a diesel engine with direct injection diesel-biodiesel-butanol fuel blends, Fuel, vol. 268, p. 117321, 2020.

J. G. T. Reyes, E. N. Quiros, Determination of the Start and End of Combustion in a Direct Injection Diesel Engine Using the Apparent Heat Release Rate, in Volume 1: Boilers and Heat Recovery Steam Generator; Combustion Turbines; Energy Water Sustainability; Fuels, Combustion and Material Handling; Heat Exchangers, Condensers, Cooling Systems, and Balance-of-Plant, 2017.

J. Pain, Gas Dynamics, Nature, vol. 213, pp. 1182–1182, 1967.

M. Canakci, Combustion characteristics of a turbocharged DI compression ignition engine fueled with petroleum diesel fuels and biodiesel, Bioresource Technology, vol. 98, pp. 1167–1175, 2007.

S. Murillo, J. L. Míguez, J. Porteiro, E. Granada, J. C. Morán, Performance and exhaust emissions in the use of biodiesel in outboard diesel engines, Fuel, vol. 86, pp. 1765–1771, 2007.

A. Saravanan, M. Murugan, M. Sreenivasa Reddy, S. Parida, Performance and emission characteristics of variable compression ratio CI engine fueled with dual biodiesel blends of Rapeseed and Mahua, Fuel, vol. 263, p. 116751, 2020.

K. A. Abed, M. S. Gad, A. K. El Morsi, M. M. Sayed, S. A. Elyazeed, Effect of biodiesel fuels on diesel engine emissions, Egyptian Journal of Petroleum, vol. 28, pp. 183–188, 2019.

H. C. Ong, H. H. Masjuki, T. M. I. Mahlia, A. S. Silitonga, W. T. Chong, T. Yusaf, Engine performance and emissions using Jatropha curcas, Ceiba pentandra and Calophyllum inophyllum biodiesel in a CI diesel engine, Energy, vol. 69, pp. 427–445, 2014.

M. S. Gad, R. El-Araby, K. A. Abed, N. N. El-Ibiari, A. K. El Morsi, G. I. El-Diwani, Performance and emissions characteristics of CI engine fueled with palm oil/palm oil methyl ester blended with diesel fuel, Egyptian Journal of Petroleum, vol. 27, pp. 215–219, 2018.

F. K. El-Baza, M. S. Gadb, S. M. Abdoc, K. A. Abedd, I. A. Mattere, Performance and exhaust emissions of a diesel engine burning algal biodiesel blends, Fuel, vol. 10, p. 11, 2016.

K. A. Abed, A. K. El Morsi, M. M. Sayed, A. A. El Shaib, M. S. Gad, Effect of waste cooking-oil biodiesel on performance and exhaust emissions of a diesel engine, Egyptian journal of petroleum, vol. 27, pp. 985–989, 2018.


  • There are currently no refbacks.

Please send any question about this web site to
Copyright © 2005-2022 Praise Worthy Prize